TASK 70-00-99-800-000
1 . General.
A.This chapter specifies each bath recommended in the cleaning and surface preparation treatment processes by solution sheets numbered SXXXX.
B.A Solution Sheet is a document that specifies composition, preparation, checking, and regeneration of a solution.
NOTE:
Two solutions which contain the same products but of different concentrations are treated as different solutions and are assigned separate solution numbers.
C.A large number of the solutions and their constituents are dangerous for human skin and clothing. It is necessary for personnel to be well protected from any direct contact by wearing aprons, gloves, and protective goggles or face shields when working with these types of solutions. For this type of situation, the preparation instructions will be preceded by a WARNING note, as per the following example.
WARNING:
ALKALINE SOLUTIONS ARE VERY ACTIVE AND CAN CAUSE SERIOUS BURNS. AVOID CONTACT WITH SKIN, EYES, AND CLOTHING. IF CONTACT OCCURS, WASH IMMEDIATELY WITH AN ABUNDANT QUANTITY OF WATER. AVOID BREATHING OF VAPORS.
WARNING:
OPERATOR SHOULD WEAR A FACE SHIELD, GLOVES, PROTECTIVE CLOTHING, AND PROTECTIVE SHOES.
D.The preparation and regeneration must be performed according to the order detailed in the procedures for preparing and regenerating the solution.
(1)Never pour water into concentrated acid.
(2)Pour the acid, alkali, or oxidizing agent very slowly into the water, small quantities at a time, without producing any splashing and with stirring after each addition.
E.The preparation, checking, and regeneration of a solution must be accomplished with the guidance and responsibility of an experienced chemist.
F.In cases where the supplier of the chemicals used in the preparation, checking, and regeneration of the following solutions is recommending a newer, up-dated analytical control procedure, that new procedure may be substituted for the control procedures recommended in this 70-00-99 section, but the data showing correlation of results must be provided comparing the two methods of analysis.
2 . Water for Electrolytic and Chemical Treatment Baths.
Subtask 70-00-99-800-235
G.Most of the baths, unless otherwise specified, are of the aqueous solution type. The water type is specified in Chapter 70-00-05.
3 . Composition of Baths.
Subtask 70-00-99-800-236
H.The chemical compositions of the baths are expressed in ounces per US gallon; grams per liter for solid products; fluid ounces per US gallon; and milliliters per liter for liquid products.
4 . Special Recommendations.
Subtask 70-00-99-800-237
I.Monitoring of Baths.
(1)The personnel utilizing the baths must be familiar with the characteristics and the performance of the baths. It is recommended that a record sheet for each bath be maintained which documents the following data.
(a)The typical composition, the limits of use, and the working conditions.
(b)The date and results of analyses accomplished:
1After preparation.
2During operation.
(c)The date and activity accomplished, such as additions, purifications, and regenerations, after special analyses or tests indicate corrective action is required.
(2)An analysis test method (titration, instrumental methods, etc.) and sampling practice are required. If a specific method is not given in the applicable solution sheet, the manufacturer’s recommended methods should be followed. It is permitted to use an alternative method that is equivalent to the manufacturer’s recommended method. A method should be developed locally if there is no manufacturer’s recommended method. All frequency of testing statements (weekly, monthly, etc.) in this section are recommendations. Chemical depletion is a function of tank volume and throughput volume. Shops should have a quality plan based on statistical process control to sample the chemical tanks to make sure that they remain within control limits. Changes in throughput or part mix may require a return to more frequent sampling to assure control. The testing method and frequency must be documented in the internal shop quality plan.
J.Verification of the Equipment.
(1)Periodically verify the general state of tanks, of tank heating systems, of bath stirring facilities, and of vapor and fumes removal devices.
(2)Periodically verify the accuracy of measurement and control apparatus, such as voltmeters, ammeters, thermometers, densimeters, rheostats, pH-meters, and other apparatus that is utilized to monitor and control the baths.
5 . Table of Solutions.
Subtask 70-00-99-800-238
 
NO.
NAME
CHAPTER
 
S0001
50:50 Nitric Acid Stripping Solution
70-23-06
70-23-07
70-23-12
70-23-24
70-23-25
 
S0002
Stripping Solution for Pure Aluminum Thermal Spray
70-23-08
70-23-18
 
S0003
Stripping Tungsten Carbide Thermal Sprayed Coating
70-23-09
 
S0004
Stripping Bond and Finish Coatings
70-23-07
 
S0005
Plating Remover for Nickel or Silver Plate
70-23-04
 
S0006
Chemical Stripping of Chromium Plate
70-23-05
 
S0007
Electrolytic Plating Remover of Chromium Plate
70-23-05
 
S0008
Deleted
 
S0009
Stripping Tungsten or Chrome Carbide Thermal Spray
70-23-11
 
S0010
Stripping Nickel Plate
70-23-13
 
S0011
Stripping Solution for Epoxy Resin
70-23-14
 
S0012
Stripping Anodized Coating from Aluminum
70-23-15
 
S0013
50:50 Nitric/Phosphoric Acid Stripping Solution
70-23-16
 
S0014
Oxidizing Alkaline Cleaners
70-23-16
 
S0015
Stripping Aluminum Honeycomb Bonded with Narmco Metalbond 328
70-23-17
 
S0016
Stripping of Alumina-nickel Aluminum Composite and Duplex Coatings
70-23-18
 
S0017
Cyanide Stripping Aluminum Oxide/Nickel Aluminide Coatings
70-23-19
 
S1001
Alkaline Permanganate Solution - C04-058
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
 
S1002
Deleted. Replaced by S1191

 
S1003
Alkaline Degreasing/Rust Removing Solution for Titanium - C04-009
70-21-09
70-22-02
 
S1004
Alkaline Permanganate Solution - Caustic Soda Plus Potassium Permanganate
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
 
S1005
Deleted

 
S1006
Alkaline Degreasing/Rust Removing Solution - C04-009
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
70-22-01
 
S1007
Oxide Conditioning Solution for Titanium - C04-080
70-22-02
 
S1008
Phosphoric Acid Solution with Inhibitor - C04-119
70-21-16
70-21-17
70-21-20
 
S1009
Acid Stripping Solution for Stainless Steel and Heat-resistant Alloys
70-21-10
70-21-20
 
S1010
Alkaline Degreasing/Rust Removing Solution for Titanium - Turco Vitroklene
70-21-09
70-22-02
 
S1011
Deleted

 
S1012
Alkaline Permanganate Solution - C04-054
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
 
S1013
Acid Stripping Solution for Titanium - Nitric Acid Plus Turco 4104
70-21-13
70-22-02
70-22-12
 
S1014
Alkaline Permanganate Solution - C04-055
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
 
S1015
Deleted

 
S1016
Phosphoric Acid Solution with Inhibitor - C04-120
70-21-16
70-21-17
70-21-20
 
S1017
Heavy Duty Alkaline Cleaner - C04-187
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
 
S1018
Alkaline Permanganate Solution - C04-188
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
 
S1019
Titanium Scale Conditioner - Ardrox 1630
70-22-02
 
S1020
Phosphoric Acid Solution with Inhibitor - C04-190
70-21-16
70-21-17
70-21-20
 
S1021
Acid Stripping Solution for Stainless Steel and Heat-resistant Alloy - Ardrox 1873
70-21-10
70-21-20
 
S1022
Phosphoric Acid Solution with Inhibitor - C04-121
70-21-16
70-21-17
70-21-20
 
S1023
Acid stripping Solution for Stainless Steel and Heat-resistant Alloy - Ardrox 1871
70-21-10
70-21-20
 
S1024
Alkaline Degreasing/Rust Removing Solution - C04-052
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
 
S1025
Alkaline Cleaning Solutions
70-21-03
70-22-03
70-46-01
 
S1026
Alkaline Degreasing/Rust Removing Solution - C04-049
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
 
S1027
Deleted

 
S1029
Acid Stripping Solution for Titanium - Nitric Acid Plus Ardrox 1635
70-21-13
70-22-02
70-22-12
 
S1030
Alkaline Degreasing Solution - Cee-Bee C-46
70-21-09
70-22-02
 
S1031
Deleted

 
S1034
Deleted

 
S1035
Deleted
70-21-08
 
S1036
Deleted

 
S1037
Deleted

 
S1038
Heavy Duty Alkaline Cleaner - C04-048
70-21-07
 
S1039
Solvent Solution - C04-030
--
 
S1040
Solvent Solution - Stoddard Solvent
70-21-01
 
S1041
Magnetic-particle Suspension Solution
70-32-01
70-33-11
 
S1046
Solution for Ultrasonic Cleaning Compound Cleaner - C04-191
70-21-15
 
S1047
Solution for Ultrasonic Cleaning - Sodium Carbonate Plus Triton X100
70-21-15
 
S1048
Wet Abrasive Blasting with C10-042
70-21-05
 
S1050
Wet Abrasive Blasting - Aluminum Oxide 325 Grit
70-21-05
 
S1053
Deleted

 
S1054
Wet Abrasive Blasting - Aluminum Oxide 500 Grit
70-21-05
 
S1103
Deleted

 
S1104
Phosphoric Acid Solution with Inhibitor - C04-143
70-21-16
70-21-17
70-21-20
 
S1123
Developer - Ardrox 9D71
70-32-02
 
S1124
Developer - Zyglo ZP5A
70-32-02
 
S1125
Developer - Zyglo ZP13A
70-32-02
 
S1126
Developer - Fluro-Chek WD
70-32-02
 
S1127
Remover - Ardrox 9PR4
70-32-02
 
S1128
Remover - Zyglo ZR10A
70-32-02
 
S1129
Remover - Fluro-Chek E41
70-32-02
 
S1130
Silicone Rubber Remover Solution - Turco 6045
70-23-20
 
S1131
Silicone Rubber Remover Solution - Cee-Bee C-105HF
70-23-20
 
S1132
Silicone Rubber Remover Solution - Ardrox 2204
70-23-20
 
S1133
Plating Remover Solution - C04-155
70-23-21
 
S1134
ASC 2-N Acid Stripping Solution
70-23-21
 
S1135
50/50 Nitric/Phosphoric Acid Stripping Solution

 
S1136
AIO Acid Stripping Solution

 
S1137
Acid Stripping Solution for NiCrAlY Plasma Coatings
70-23-22
 
S1138
Acidic Stripper for Plasma and D-gun Deposited Coatings
70-23-09
 
S1139
Alkaline Degreasing/Rust Removing Solution for Titanium - C04-049
70-21-09
70-22-02
 
S1140
Alkaline Degreasing/Rust Removing Solution - C04-052
70-21-09
70-22-02
 
S1141
Light Duty Alkaline Cleaning Solution - C04-163
70-21-22
 
S1142
Light Duty Alkaline Cleaner - Turco 5948R
70-21-22
70-46-01
 
S1143
Light Duty Alkaline Cleaner - CO4-164
70-21-22
70-46-01
 
S1144
Light Duty Alkaline Cleaner - C04-165
70-21-22
 
S1145
Light Duty Alkaline Cleaner - C04-168
70-21-22
70-22-07
70-46-01
 
S1146
Versene Cleaning of Codep Coated HPTR Blades
70-22-07
 
S1147
Solvent Solution - Degreasol 99R
70-21-01
70-22-09
 
S1148
Light Duty Alkaline Cleaner - Jettacin
70-21-22
 
S1149
Ammonium Versene Cleaning Solution
70-22-08
 
S1150
Alkaline Degreasing/Rust Removing Solution - C04-182
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
70-22-01
70-23-02
 
S1151
Alkaline Degreasing Solution for Titanium - C04-182
70-21-09
70-21-10
70-22-02
 
S1152
Acid Stripping Solution for Stainless Steel and Heat-resistant Alloys - C04-183
70-21-10
70-21-20
 
S1153
Deleted

 
S1154
Light-duty Alkaline Cleaner - C04-184
70-21-22
 
S1155
Paint and Carbon Remover - C04-185
70-21-08
70-23-01
 
S1156
In-process Corrosion Inhibitor Solution for Steel - C02-072
70-60-00
 
S1157
Deleted

 
S1158
Light Duty Alkaline Cleaner - Mag-Chem Soluwax
70-21-22
 
S1159
Acid Stripping Solution for Stainless Steel and Heat-resistant Alloys
70-21-10
70-21-20
 
S1160
Paint and Carbon Remover - C04-194
70-21-08
70-23-01
 
S1161
Alkaline Degreasing/Rust Removing Solution - C04-212
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
 
S1162
Alkaline Degreasing/Rust Removing Solution - C04-213
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
 
S1163
Alkaline Permanganate Solution - C04-214
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
 
S1164
Alkaline Permanganate Solution - C04-215
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
 
S1165
Acid Stripping Solution for Stainless Steel and Heat-resistant Alloys - C04-216
70-21-10
70-21-20
 
S1166
Phosphoric Acid Solution with Inhibitor - C04-217
70-21-16
70-21-17
70-21-20
 
S1167
Plating for Nickel or Silver Plate
70-21-22
 
S1168
Alkaline Degreasing/Rust Removing Solution for Titanium - C04-212/C04-213
70-21-09
70-22-02
 
S1169
Solution for Inspection of Open Face Honeycomb
70-32-02
 
S1170
Light Duty Alkaline Cleaner - Super Bee 300LF
70-21-22
70-21-24
 
S1171
Paint and Carbon Remover - C04-105
70-23-01
 
S1172
Abradable Plastic Seal Compound (RSP-3)
70-43-15
 
S1173
Chromated Conversion Coating - C03-006 or C03-083
70-43-08
 
S1174
Chromated Conversion Coating - C03-046
70-43-08
 
S1175
Alkaline Degreasing/Rust Removing Solution for Titanium Parts - C04-233
70-21-09
70-22-02
 
S1176
Alkaline Degreasing/Rust Removing Solution for Non-Titanium Parts - C04-233
70-21-06
70-21-07
70-21-10
70-21-16
70-21-17
70-21-20
 
S1177
Alkaline Permanganate Solution - C04-234
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
 
S1178
Phosphoric Acid Solution with Inhibitor - C04-235
70-21-16
70-21-17
70-21-20
 
S1179
Acid Stripping Solution for Stainless Steel and Heat-Resistant Alloys - C04-236
70-21-10
70-21-20
 
S1180
Light-Duty Alkaline Cleaner - C04-208
70-21-22
 
S1181
Light-Duty Alkaline Cleaner - C04-193
70-21-22
 
S1182
Light-Duty Alkaline Cleaner - C04-237
70-21-22
 
S1183
Acid Stripping Solution for Stainless Steel and Heat-Resistant Alloys - C04-239 (for Cee-Bee J-3 product only)
70-21-10
70-21-20
 
S1184
Acid Stripping Solution for Stainless Steel and Heat-Resistant Alloys - C04-240 (for Ardrox 1873A product only)
70-21-10
70-21-20
 
S1185
Phosphoric Acid Solution with Inhibitor - C04-122
70-21-16
70-21-17
70-21-20
 
S1186
Plating Remover Solution - C04-244
70-23-21
 
S1187
Paint and Carbon Remover - C04-245
70-21-08
70-23-01
 
S1188
Plating Remover for Nickel or Silver Plate - C04-246
70-23-04
 
S1189
Alkaline Rust Remover - C04-247
70-22-03
70-22-05
 
S1190
Hydrochloric Acid Stripping Solution
70-21-13
70-22-02
70-22-12
 
S1191
Acid Stripping Solution for Titanium - Nitric Acid Plus Ammonium Bifluoride
70-21-13
70-22-02
70-22-12
 
S1192
Acid Stripping Solution for Titanium - Nitric Acid Plus Cee-Bee P-109
70-21-13
70-22-02
70-22-12
 
S1196
Magnesium Hydroxide Suspension
None
 
S1198
Alkaline Cleaning Solution - C04-052
70-22-01
 
S1199
Alkaline Cleaning Solution - C04-009
70-22-01
 
S1200
Solution for Inspection of Open Face Honeycomb
70-33-02
 
S1201
Deleted

 
S1202
Deleted

 
S1203
Alkaline Permanganate Cleaner (C04-273)
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
70-22-12
 
S1204
Light Duty Alkaline Cleaning Solution - C04-267
70-21-22
 
S1205
Alkaline Permanganate Cleaner C04-279
70-21-07
70-21-10
70-21-17
70-21-20
70-22-02
70-22-05
70-22-12
70-23-26
 
S1206
Acid Stripping Solution for Ni-Cr-Al-Y Plasma Coatings on Rene 88DT
70-23-28
 
S1207
Light Duty Alkaline Cleaner - C04-289
70-21-22
 
S1208
Neutral Deoxidizing/Rust Removing Solution - C04-290
70-21-07
 
S1209
Aqueous Cleaner for Cleanliness Inspection - C04-015
70-21-15
70-22-07
70-22-80
 
S1210
Aqueous Cleaner for Cleanliness Inspection - C04-293
70-22-80
 
S1211
Light Duty Alkaline Cleaner - C04-296
70-21-22
 
S1212
Non-Chromated Conversion Coating - C03-114
70-43-07
70-43-18
 
S1213
Coke Removing Solution
--